Stability Analysis and Design of Pressure Control System
Article Sidebar
Main Article Content
Abstract
The performance of pressure control system and stability analysis was studied for different types of controllers. A theoretical model for closed-loop system is developed and dynamic behavior of the control system was studied by introducing a step change in the pressure of the inlet stream. The results show that the theoretical response is faster than the experimental response due to the lags of the control valve and measuring elements. The pressure control system is stable for all conditions and for different control action because the real parts of roots of characteristics equation are negative but the response at PID controller is oscillatory stable. when PID controller used the response is improve due to eliminate the offset and stabilizing effect of derivative allow the proportional gain to be increased and increasing the speed of response compared to proportional and proportional integral controllers.
Metrics
Article Details
This work is licensed under a Creative Commons Attribution 4.0 International License.
THIS IS AN OPEN ACCESS ARTICLE UNDER THE CC BY LICENSE http://creativecommons.org/licenses/by/4.0/
Plaudit
References
Hougen, J. O., Experimental Studies Measurements and Control Applications , ISA, 1979.
Fletcher, I., Arden, W.J.B. & Cox, C.S., Multivariable Control Strategies applied to a Gas Pressure Reduction Station’, 4th International Symposium on ‘Applications of Multivariable System Techniques’, Bradford University, ISBN, pp128-136, 1990.
French, I. G., Fletcher, I., and Ng, S., ‘Control of a Gas Scrubber Process’, Proc. International Conference ‘Control 91’, Heriot-Watt University, pp596-601, 1991.
Fletcher, I., Burn, K.,Arden, W.J.B. Fuzzy Control of a two-stage High Pressure Gas Reduction Station , Int. Conference on Applications of Multivariable System Techniques, University of Bradford, April 1998.
Harris, J., : Fuzzy Logic Applications in Engineering Science”, Springer/ Netherlands, pp. 136-150, 2006. DOI: https://doi.org/10.1007/1-4020-4078-4
Zlokovitz, R., Development of Predictive Control Hardware and Adaptive Algorithm for District Regulators , Gas Research Institute research program, 1989.
Zlokovitz, R., Randy, G., Optimizing Low Pressure District Regulator Stations , Gas Research Institute research program, 1990.
Alessandro, Pontremoli, Modeling and Control of a Paper Dryer Section Using Modelica , Master thesis, Lund Institute of Technology, November, 2000.
Luyben, W., ” Autotuning of PID Controllers”, Spring-Verlag, London limited, pp. 167-173, 2006.
Johan, Gagner, Adaptive Realtime Control of a Nonlinear Throttle Unit , Master thesis, Lund Institute of Technology, February, 2000.
John, A., Gas/Liquid Phase Separator With Improved Pressure Control ,United State Patent No. 2003/0201187A1, October, 2003.
Bernd, R., Tobios, E., Tomas, M., and Maiaberg, U., Pressure Control Devise and Method for Programmer Controlled Actuation of a Pressure Regulating Mechanism , United State Patent No. 2003/0149519A1, Aug., 2003.
Frank, R., Gas Pressure/Flow Control and Recovery System United State Patent No.2003/0136176A1, 2003.